合肥工业大学校徽

合肥工业大学学报自科版

合肥工业大学学报(自然科学版)

JOURNAL OF HEFEI UNIVERSITY OF TECHNOLOGY (NATURAL SCIENCE)

主管：中华人民共和国教育部

主办：合肥工业大学

ISSN 1003-5060, CN 34-1083/N

微通道纳米强化相变微胶囊悬浮液流动与传热实验

Experiments on flow and heat transfer of nano-enhanced micro-encapsulated phase change material slurry in microchannel

期刊信息

合肥工业大学（自然科学版），2025年4月，第48卷第4期：455-461

DOI: 10.3969/j.issn.1003-5060.2025.04.004

作者信息

朱华星，杨磊

（合肥工业大学汽车与交通工程学院，安徽合肥230009）

摘要和关键词

摘要: 文章设计了微通道流动与传热实验平台, 针对定制的 $ Fe_{3}O_{4} $ 纳米颗粒强化相变微胶囊悬浮液 (microencapsulated phase change material slurry, MPCS) 开展循环流动实验, 分别从微通道压降、摩擦阻力系数、对流换热系数、微通道板温度等 4 个方面探究 MPCS 在微通道中的流动与传热特性。实验结果表明: MPCS 在微通道中的压降随质量分数的增加而增大, 且明显高于去离子水; 与之相比, $ Fe_{3}O_{4} $-MPCS 在微通道中的压降并无显著变化。此外, 微尺度流动可能更有利于在 Re 较小时产生湍流; MPCS 的对流换热系数高于去离子水, 且随 Re 及质量分数的增大而增大, 微通道的板温度更低, 表现出更好的冷却效果; 相同质量分数的 $ Fe_{3}O_{4} $-MPCS 具有更高的对流换热系数, 传热性能更佳; 在低 Re 下较低的热流密度更有利于传热, 在 Re 较高时高热流密度下传热效果更佳。

关键词: 相变微胶囊；纳米强化；微通道；传热；流动特性

Authors

ZHU Huaxing, YANG Lei

(School of Automobile and Traffic Engineering, Hefei University of Technology, Hefei 230009, China)

Abstract and Keywords

Abstract: In this paper, a microchannel flow and heat transfer platform was designed to carry out circulation flow experiments on customized $ Fe_{3}O_{4} $ nanoparticle enhanced micro-encapsulated phase change material slurry ( $ Fe_{3}O_{4} $-MPCS). The flow and heat transfer characteristics of MPCS in microchannel were experimentally researched from four aspects: pressure drop, friction resistance coefficient, convective heat transfer coefficient and microchannel plate temperature. The results show that the pressure drop of MPCS in microchannel increases with the increase of mass fraction, which is significantly higher than that of deionized water. In contrast, the pressure drop of $ Fe_{3}O_{4} $-MPCS in microchannel has no obvious change. In addition, microscale flow may be more conducive to the emergence of turbulence with smaller Re. It is shown that the convective heat transfer coefficient of MPCS is higher than that of deionized water, and increases with the increase of Re and mass fraction. The microchannel plate temperature is correspondingly lower, indicating better cooling effect. $ Fe_{3}O_{4} $-MPCS with the same mass fraction has a higher convective heat transfer coefficient and better heat transfer performance. The experimental results also indicate the influence of heat flux density on heat transfer performance. When Re is low, lower heat flux density is more conducive to heat transfer; when Re is high, higher heat flux density is better for heat transfer.

Keywords: micro-encapsulated phase change material; nano-enhanced; microchannel; heat transfer; flow characteristic

基金信息

安徽省自然科学基金资助项目（JZ2019AKZR0218）

前一篇后一篇

返回期刊目录